A dual-motor drive system for scraper conveyor
-
摘要: 目前对刮板输送机采用永磁同步电动机驱动的研究大多通过改造驱动系统的机械结构提升效率,对永磁同步电动机优化控制算法的研究较少。针对该问题,将最大转矩电流比(MTPA)控制和弱磁控制引入刮板输送机双机驱动系统中:电动机运行于额定转速以内时,采用MTPA控制,通过给定直轴电流实现单位电流最大转矩输出,以降低电动机损耗;通过弱磁控制扩大刮板输送机的调速范围,以适应不同生产负载场景,保证刮板输送机出煤量相对稳定。针对刮板输送机双机功率不平衡的问题,采用主从控制方式,将机尾电动机作为主机,机头电动机作为从机,将主机的转矩给定传输至从机的MTPA控制和弱磁控制中,实现功率平衡。在AMEsim中搭建刮板输送机有限元仿真模型,在Matlab/Simulink中搭建刮板输送机双机驱动系统仿真模型,通过AMEsim与Matlab/Simulink联合仿真验证双机驱动系统控制策略的有效性,结果表明:电动机突然加大负载后,在MTPA控制下定子电流稳定在130.1 A,而在传统矢量控制下定子电流稳定在149.2 A,在相同输出转矩下,输出定子电流越小越好,因此MTPA控制的优势比较明显;弱磁控制将电动机的调速范围从0~750 r/min扩大到0~850 r/min;主从控制方式能够使从机与主机转矩一致,实现双机功率平衡。Abstract: Current scraper conveyors with permanent magnet synchronous motors often improve their efficiency by updating the mechanical structure of their drive systems, few efforts are made to optimize the control of permanent magnet synchronous motors. This paper fills the gap by involving maximum torque per ampere (MTPA) and flux-weakening controls to improve the dual-motor drive system of scraper conveyors. Given the direct-axis current, the proposed system reduces the motor loss by adopting MTPA control to obtain the maximum torque per ampere. By using flux-weakening control to increase the speed regulation range of scraper conveyors, the coal output of a scraper conveyor can be relatively stable under various production loads. To balance the power of two motors, the proposed system applies the master-slave control that takes the rear motor as the master and the front motor as the slave, and gives the master's torque setpoint to the slave's MTPA and flux-weakening control systems. The effectiveness of the proposed system is evaluated by using AMEsim and Matlab/Simulink to simulate the scraper conveyor and its dual-motor drive system, respectively. The results show that the stator current under MTPA can be stable at 130.1 A when the motor load suddenly raised, while the stator current under traditional vector control is stable at 149.2 A. MTPA control outperforms the vector control, as the smaller stator current implies the better system when the same output torque maintained. Flux-weakening control extends the speed regulation range from 0-750 r/min to 0-850 r/min. Master-slave control maintains the same output torques of the master and the slave, leading to the balanced dual-motor power.
-
表 1 永磁同步电动机主要参数
Table 1. The main parameters of permanent magnet synchronous motor
参数 值 参数 值 额定电压/V 3 300 额定功率/kW 1 000 额定转速/(r·min−1) 750 极对数 4 Lq/mH 10.2 Ld/mH 37.9 永磁体磁链/Wb 5.7 电枢电阻/Ω 0.081 6 -
[1] 阚乃杰,吴家成. 矿用刮板输送机隔爆型三相永磁半直驱电机开发及应用[J]. 防爆电机,2019,54(5):14-18. doi: 10.3969/J.ISSN.1008-7281.2019.05.06KAN Naijie,WU Jiacheng. Development and application of flame-proof semi-direct drive three-phase permanent magnet motor for mine scraper conveyor[J]. Explosion-Proof Electric Machine,2019,54(5):14-18. doi: 10.3969/J.ISSN.1008-7281.2019.05.06 [2] 刘洵文. 永磁同步电动机在煤矿装备上的应用展望[J]. 煤矿机械,2018,39(12):130-132.LIU Xunwen. Application prospect of permanent magnet synchronous motor in coal mine equipment[J]. Coal Mine Machinery,2018,39(12):130-132. [3] 耿嘉胜. 永磁变频驱动刮板输送机集控系统研究[D]. 太原: 太原理工大学, 2020.GENG Jiasheng. Research on centralized control system of scraper conveyor driven by permanent magnet variable frequency motor[D]. Taiyuan: Taiyuan University of Technology, 2020. [4] 王洋洋,鲍久圣,葛世荣,等. 刮板输送机永磁直驱系统机−电耦合模型仿真与试验[J]. 煤炭学报,2020,45(6):2127-2139.WANG Yangyang,BAO Jiusheng,GE Shirong,et al. Simulation and experimental study on electromechanical coupling model of permanent magnet direct drive system for scraper conveyor[J]. Journal of China Coal Society,2020,45(6):2127-2139. [5] 潘旭陽. 刮板输送机高密度永磁直驱电机设计及机−电−控系统耦合研究[D]. 阜新: 辽宁工程技术大学, 2021.PAN Xuyang. Design of high density permanent magnet direct drive motor for scraper conveyor in coal mine research on the coupling of mechanical electrical control system[D]. Fuxin: Liaoning Technical University, 2021. [6] 张小牛. 刮板输送机永磁电机驱动系统控制策略研究[D]. 徐州: 中国矿业大学, 2020.ZHANG Xiaoniu. Study on the control strategy of permanent magnet direct-drive system for scraper conveyor[D]. Xuzhou: China University of Mining and Technology, 2020. [7] 路恩. 矿用刮板输送机永磁直驱系统速度控制策略研究[D]. 徐州: 中国矿业大学, 2018.LU En. Study on the speed control strategy of permanent magnet direct-drive system for mining scraper conveyor[D]. Xuzhou: China University of Mining and Technology, 2018. [8] 舒子龙. 永磁电机半直驱刮板输送机动态特性研究[D]. 徐州: 中国矿业大学, 2019.SHU Zilong. Research on dynamic characteristics of permanent magnet motor semi-direct drive scraper conveyor[D]. Xuzhou: China University of Mining and Technology, 2019. [9] 王腾. 双机驱动刮板输送机的电机功率不均机理研究[EB/OL]. [2021-11-12]. https://wenku.baidu.com/view/dd491147b307e87101f6966e?fr=xueshu_top.WANG Teng. Research on the mechanism of uneven motor power of dual-motor drive scraper conveyor[EB/OL]. [2021-11-12]. https://wenku.baidu.com/view/dd491147b307e87101f6966e?fr=xueshu_top. [10] 李艳伟,李小凡. 刮板输送机两机驱动下功率不平衡研究[J]. 煤炭工程,2013,45(10):86-88. doi: 10.11799/ce201310029LI Yanwei,LI Xiaofan. Research on power imbalance of scraper conveyor driven by two motors[J]. Coal Engineering,2013,45(10):86-88. doi: 10.11799/ce201310029 [11] 王超. 基于可控启动的刮板输送机首尾功率平衡研究[J]. 自动化应用,2020(1):75-77.WANG Chao. Research on power balance of scraper conveyor based on controlled startup[J]. Automation Application,2020(1):75-77. [12] 毛君,曹昊,谢苗. 刮板输送机首尾电动机功率平衡控制研究[J]. 煤炭科学技术,2017,45(2):130-135.MAO Jun,CAO Hao,XIE Miao. Study on power balance control of head and tail electric motors applied to scraper conveyor[J]. Coal Science and Technology,2017,45(2):130-135. [13] 陈梓怀. 电动汽车用内置式永磁同步电机效率优化控制策略研究[D]. 武汉: 华中科技大学, 2016.CHEN Zihuai. Research on efficiency optimization control strategy of interior permanent magnet synchronous motor for electric vehicle[D]. Wuhan: Huazhong University of Science and Technology, 2016. [14] 方晓春,胡太元,林飞,等. 基于交直轴电流耦合的单电流调节器永磁同步电机弱磁控制[J]. 电工技术学报,2015,30(2):140-147. doi: 10.3969/j.issn.1000-6753.2015.02.019FANG Xiaochun,HU Taiyuan,LIN Fei,et al. Single current regulator flux-weakening control of PMSM based on current cross-coupling effect[J]. Transactions of China Electrotechnical Society,2015,30(2):140-147. doi: 10.3969/j.issn.1000-6753.2015.02.019 -