| Citation: | ZHOU Yabo, WU Binjie, BAI Yang, et al. Classification of safety zones for T-shaped roadway fire in deep coal mines[J]. Journal of Mine Automation，2023，49（12）：130-138. doi: 10.13272/j.issn.1671-251x.2023040024
|
The flow and diffusion of high-temperature smoke in mine fires is an important cause of safety accidents. In response to the unclear relationship between fire hazard zones and time in typical mine roadways, a safety zone classification method for T-shaped roadway fire in deep coal mines is proposed. A three-dimensional numerical model is established using Pyrosim software to simulate the high-temperature smoke flow in the T-shaped roadway during the fire development stage under high temperature and humidity conditions. The variation law of temperature field and CO, CO2 concentration field with time and spatial location in the T-shaped roadway during the fire development stage are revealed. Based on the simulated data of the height of the human mouth and nose (i.e. the height of 1.6 meters in the roadway), the relationship between the horizontal length of the roadway and temperature, CO concentration and CO2 concentration is obtained. The airflow mixes high-temperature smoke through the roadway and spreads downwards along the top of the roadway. As the distance from the fire source increases, the temprature gradually decreases, and the longitudinal distribution of CO and CO2 concentration contour lines becomes denser. On this basis, safety zones are classified based on the temperature of the smoke and the harm degree of CO and CO2 concentration to human health. The smoke diffusion area is divided into four categories: safety zone (hazard level 1), mild hazard zone (hazard level 2), moderate hazard zone (hazard level 3), and severe hazard zone (hazard level 4). The analysis results show that in the temperature classification results, the measurement points in roadwayⅠare mainly concentrated in the severe hazard zone. In the toxic gas classification results, the safety zone range of CO2 in roadway Ⅰ is larger than that of CO. The risk factors for CO are greater, mainly concentrated in mild and moderate hazard zones. In roadway Ⅱ, it is mainly concentrated in mild hazard zones. The range of hazard level 1 in roadway Ⅰ gradually decreases over time, while the range of hazard level 4 gradually increases over time, with the maximum change rate occurring at 40 seconds. The rates of change for hazard levels 2 and 3 are very small. The regional range changes of the two classification methods in roadway Ⅱ are similar, with the maximum change rate of hazard levels 2 and 3 occurring at 60 seconds.
| [1] |
CHUAN Gangfan,XU Yanli,YAN Mu,et al. Smoke movement characteristics under stack effect in a mine laneway fire[J]. Applied Thermal Engineering,2017,110:70-79. doi: 10.1016/j.applthermaleng.2016.08.120
|
| [2] |
SHI Xueqiang,ZHANG Yutao,CHEN Xiaokun,et al. Effects of thermal boundary conditions on spontaneous combustion of coal under temperature-programmed conditions[J]. Fuel,2021,295(15). DOI: 10.1016/j.fuel.2021.120591.
|
| [3] |
LIU Yin,WEN Hu,GUO Jun,et al. Coal spontaneous combustion and N2 suppression in triple goafs:a numerical simulation and experimental study[J]. Fuel,2020,271. DOI: 10.1016/j.fuel.2020.117625.
|
| [4] |
GUO Jun,WEN Hu,ZHENG Xuezhao,et al. A method for evaluating the spontaneous combustion of coal by monitoring various gases[J]. Process Safety and Environmental Protection,2019,126:223-231. doi: 10.1016/j.psep.2019.04.014
|
| [5] |
CHOW WK,GAO Y,ZOU JF,et al. Numerical studies on thermally-induced air flow in sloping tunnels with experimental scale modelling justifications[J]. Fire Technology,2018,54(4):867-892. doi: 10.1007/s10694-018-0713-3
|
| [6] |
GUO Jun,LIU Yin,CHENG Xiaojiao,et al. A novel prediction model for the degree of rescue safety in mine thermal dynamic disasters based on fuzzy analytical hierarchy process and extreme learning machine[J]. International Journal of Heat and Technology,2018,36(4):1336-1342. doi: 10.18280/ijht.360424
|
| [7] |
WEN Hu,LIU Yin,GUO Jun,et al. A multi-index-classified early warning method for spontaneous combustion of coal under air leakage blocking[J]. International Journal of Oil,Gas and Coal Technology,2021,27(2):208-226. doi: 10.1504/IJOGCT.2021.115547
|
| [8] |
薛彦平. 巷道分岔角度对火灾烟气蔓延的影响数值模拟[J]. 煤矿安全,2020,51(6):179-183. doi: 10.13347/j.cnki.mkaq.2020.06.039
XUE Yanping. Numerical simulation of effect of tunnel diverging angles on fire smoke flow[J]. Safety in Coal Mines,2020,51(6):179-183. doi: 10.13347/j.cnki.mkaq.2020.06.039
|
| [9] |
ZHAO Shengzhong,LIU Fang,WAGN Jun,et al. Experimental investigation on fire smoke bifurcation flow in longitudinal ventilated tunnels[J]. Fire and Materials,2020,44(5). DOI: 10.1002/fam.2828.
|
| [10] |
HUANG Youbo,LI Yanfeng,LI Junmei,et al. Experimental investigation on maximum gas temperature beneath the ceiling in a branched tunnel fire[J]. International Journal of Thermal Sciences,2019,145. DOI: 10.1016/j.ijthermalsci.2019.105997.
|
| [11] |
索在斌. 工作面进风巷下行风流火灾数值模拟及风流控制研究[D]. 太原:太原理工大学,2019.
SUO Zaibin. Numerical simulation and airflow control of downstream flow fire in working face[D]. Taiyuan:Taiyuan University of Technology,2019.
|
| [12] |
王建国,武睿萌,殷雄,等. 综采工作面进风巷火灾数值模拟研究[J]. 矿业安全与环保,2019,46(5):7-11,15. doi: 10.3969/j.issn.1008-4495.2019.05.002
WANG Jianguo,WU Ruimeng,YIN Xiong,et al. Numerical simulation of fire in intake airway in fully mechanized working face[J]. Mining Safety & Environmental Protection,2019,46(5):7-11,15. doi: 10.3969/j.issn.1008-4495.2019.05.002
|
| [13] |
李祥春,蒋颖,李梅生. 巷道火灾时期流场及瓦斯浓度变化规律数值模拟研究[J]. 煤炭科学技术,2019,47(5):119-125. doi: 10.13199/j.cnki.cst.2019.05.019
LI Xiangchun,JIANG Ying,LI Meisheng. Study on numerical simulation of variations of airflow field and gas concentration during roadway fire[J]. Coal Science and Technology,2019,47(5):119-125. doi: 10.13199/j.cnki.cst.2019.05.019
|
| [14] |
索在斌,吴世跃,牛煜,等. 坡度对上行通风火灾影响的数值模拟[J]. 煤矿安全,2019,50(1):192-195,199. doi: 10.13347/j.cnki.mkaq.2019.01.047
SUO Zaibin,WU Shiyue,NIU Yu,et al. Numerical simulation of the influence of slope on upward ventilation fire[J]. Safety in Coal Mines,2019,50(1):192-195,199. doi: 10.13347/j.cnki.mkaq.2019.01.047
|
| [15] |
沈云鸽,王德明. 基于FDS的矿井巷道火灾烟气致灾的数值模拟[J]. 煤矿安全,2020,51(2):183-187. doi: 10.13347/j.cnki.mkaq.2020.02.001
SHEN Yunge,WANG Deming. Numerical simulation of smoke disaster caused by mine roadway fire based on FDS[J]. Safety in Coal Mines,2020,51(2):183-187. doi: 10.13347/j.cnki.mkaq.2020.02.001
|
| [16] |
陈亮,邬长福,陈祖云,等. 矿井巷道火灾安全区域划分数值模拟[J]. 消防科学与技术,2016,35(5):633-636. doi: 10.3969/j.issn.1009-0029.2016.05.013
CHEN Liang,WU Changfu,CHEN Zuyun,et al. Numerical simulation study on the regional division of mine roadways fire safety[J]. Fire Science and Technology,2016,35(5):633-636. doi: 10.3969/j.issn.1009-0029.2016.05.013
|
| [17] |
刘蓓蓓. 金属矿井下火灾热释放速率及烟气逆流行为研究[D]. 青岛:山东科技大学,2018.
LIU Beibei. The research of heat release rate and backlayering in the fire under the metal mine[D]. Qingdao:Shandong University of Science and Technolog,2018.
|
| [18] |
张泽. 矿井胶带火灾烟气流动模拟及危险区域划分[D]. 西安:西安科技大学,2017.
ZHANG Ze. Simulation and division of danger areas of smoke flow of belt fire in coal mine[D]. Xi'an:Xi'an University of Science and Technology,2017.
|
| [19] |
邓权龙. 矿井巷道火灾烟流数值模拟及安全区域划分[D]. 赣州:江西理工大学,2015.
DENG Quanlong. The numerical simulation of the smoke flow during fire and the safety zone divide in mine roadways[D]. Ganzhou:Jiangxi University of Science and Technology,2015.
|
| [20] |
WEN Hu,LIU Yin,GUO Jun,et al. Study on numerical simulation of fire danger area division in mine roadway[J]. Mathematical Problems in Engineering,2021. DOI: 10.1155/2021/6646632.
|
Figures(9) / Tables(10)
Supported by:
Beijing Renhe Information Technology Co. Ltd.
Visits：
DownLoad:
