Volume 49 Issue 2
Feb.  2023
Turn off MathJax
Article Contents
Article Navigation >  Journal of Mine Automation  > 2023  >  49(2): 102-108, 124
FAN Jiafeng. Study on spontaneous combustion law of residual coal in goaf under the condition of gas extraction in the low-level roadway[J]. Journal of Mine Automation，2023，49(2)：102-108, 124.  doi: 10.13272/j.issn.1671-251x.2022070031
Citation: FAN Jiafeng. Study on spontaneous combustion law of residual coal in goaf under the condition of gas extraction in the low-level roadway[J]. Journal of Mine Automation，2023，49(2)：102-108, 124.  doi: 10.13272/j.issn.1671-251x.2022070031
shu

Study on spontaneous combustion law of residual coal in goaf under the condition of gas extraction in the low-level roadway

doi: 10.13272/j.issn.1671-251x.2022070031
  • 1.

    CCTEG Shenyang Research Institute, Shenyang 110016, China

  • 2.

    State Key Laboratory of Coal Mine Safety Technology, Fushun 113001, China

  • Received Date: 2022-07-12
  • Rev Recd Date: 2023-02-10
    • Available Online: 2022-09-28
    Abstract
  • The gas extraction in the low-level roadway in the coal seam roof is an important technical measure to solve the problem of gas concentration exceeding the limit in the upper corner of the working face. But the high-flow mixed extraction in the low-level roadway causes serious air leakage in goaf and increases the risk of spontaneous combustion of residual coal. At present, there are few studies on the synergistic effect of low-level roadway layout and extraction flow on the spontaneous combustion of residual coal in goaf. According to the actual situation of gas extraction in existing goaf with the low-level roadway in 10106 working face of Jiajiagou Coal Mine, a three-dimensional fluid-solid-thermal multi-field coupling numerical model of heterogeneous goaf is established by COMSOL software. The spontaneous combustion law of residual coal in goaf induced by gas extraction in the low-level roadway is analyzed by numerical simulation. The results show that gas extraction in the low-level roadway can reduce the gas concentration in the upper corner of the working face. The gas extraction flow rate is proportional to the maximum width of the spontaneous combustion oxidation zone and the maximum temperature of goaf. With the increase of gas extraction flow rate, the maximum width of the spontaneous combustion oxidation zone and the maximum temperature of goaf will increase. But too high gas extraction pressure will cause the air near the upper corner to "flow back" to the goaf. This will increase the risk of spontaneous combustion of residual coal in goaf. When the gas extraction flow rate of low-level roadway is constant, the smaller the dislocation distance is, the larger the maximum width and the maximum temperature of the spontaneous combustion oxidation zone in goaf are. Combined with the numerical simulation results and engineering practice, it is determined that the dislocation distance in the low-level roadway of Jiajiagou Coal Mine is 15 m. The gas extraction flow rate is 45 m3/min. The gas volume fraction in the upper corner is 0.875% and the maximum width of the spontaneous combustion oxidation zone in goaf is 59.14 m. The scheme effectively solves the problem of gas concentration exceeding the limit in the upper corner. The risk area of spontaneous combustion of residual coal in goaf is not significantly increased.

     

    • FullText(HTML)
  • loading
    • References(21)
  • [1]
    YANG Shengqiang,ZHOU Buzhuang,WANG Chaojie. Investigation on coal spontaneous combustion in the gob of Y type ventilation caving face:A case study[J]. Process Safety and Environmental Protection,2021,148(2):590-603.
    [2]
    周冬,刘贞堂,钱继发,等. 采空区内煤自燃气体特征及产生规律分析[J]. 工矿自动化,2019,45(3):18-22. doi: 10.13272/j.issn.1671-251x.2018090037

    ZHOU Dong,LIU Zhentang,QIAN Jifa,et al. Analysis of gas characteristics and generation rules of coal spontaneous combustion in goaf[J]. Industry and Mine Automation,2019,45(3):18-22. doi: 10.13272/j.issn.1671-251x.2018090037
    [3]
    邓军,白祖锦,肖旸,等. 煤自燃灾害防治技术现状与挑战[J]. 煤矿安全,2020,51(10):118-125. doi: 10.13347/j.cnki.mkaq.2020.10.018

    DENG Jun,BAI Zujin,XIAO Yang,et al. Present situation and challenge of coal spontaneous combustion disasters prevention and control Technology[J]. Safety in Coal Mines,2020,51(10):118-125. doi: 10.13347/j.cnki.mkaq.2020.10.018
    [4]
    邢震. 高瓦斯矿井采空区瓦斯与煤自燃耦合规律研究[J]. 工矿自动化,2020,46(3):6-11. doi: 10.13272/j.issn.1671-251x.2019010084

    XING Zhen. Research on coupling law of gas and coal spontaneous combustion in goaf of high gas mine[J]. Industry and Mine Automation,2020,46(3):6-11. doi: 10.13272/j.issn.1671-251x.2019010084
    [5]
    王德明,邵振鲁,朱云飞. 煤矿热动力重大灾害中的几个科学问题[J]. 煤炭学报,2021,46(1):57-64.

    WANG Deming,SHAO Zhenlu,ZHU Yunfei. Several scientific issues on major thermodynamic disasters in coal mines[J]. Journal of China Coal Society,2021,46(1):57-64.
    [6]
    XU Yu,LI Zijun,ZHAI Xiaowei,et al. A model for assessing the compound risk represented by spontaneous coal combustion and methane emission in a gob[J]. Journal of Cleaner Production,2020,273(11):122925.
    [7]
    CHU Tingxiang,LI Pin,CHEN Yuexia. Risk assessment of gas control and spontaneous combustion of coal under gas drainage of an upper tunnel[J]. International Journal of Mining Science and Technology,2019,29(3):491-498. doi: 10.1016/j.ijmst.2018.05.002
    [8]
    王继仁,张英,黄戈,等. 采空区不同瓦斯抽采方法与自燃合理平衡的数值模拟[J]. 中国安全生产科学技术,2015,11(8):26-32.

    WANG Jiren,ZHANG Ying,HUANG Ge,et al. Numerical simulation on reasonable balance between different gas drainage methods and spontaneous combustion in gob area[J]. Journal of Safety Science and Technology,2015,11(8):26-32.
    [9]
    贾廷贵,李颜兵,曲国娜. 偏Y形通风工作面上隅角瓦斯抽采模拟[J]. 安全与环境学报,2021,21(6):2472-2478. doi: 10.13637/j.issn.1009-6094.2020.0624

    JIA Tinggui,LI Yanbing,QU Guona. Simulated research on the gas drainage in the upper corner of the working face with partial Y type ventilation[J]. Journal of Safety and Environment,2021,21(6):2472-2478. doi: 10.13637/j.issn.1009-6094.2020.0624
    [10]
    杜阳,翁旭泽,戚绪尧,等. 远距离抽采条件下采空区煤自燃区域分布规律[J]. 煤矿安全,2020,51(1):196-199. doi: 10.13347/j.cnki.mkaq.2020.01.044

    DU Yang,WENG Xuze,QI Xuyao,et al. Distribution law of spontaneous combustion danger zone of coal in goaf under long distance extraction[J]. Safety in Coal Mines,2020,51(1):196-199. doi: 10.13347/j.cnki.mkaq.2020.01.044
    [11]
    裴晓东,张人伟,马伟南. 高瓦斯易自燃采空区瓦斯与煤自燃耦合模拟研究[J]. 煤炭科学技术,2016,44(4):73-77. doi: 10.13199/j.cnki.cst.2016.04.015

    PEI Xiaodong,ZHANG Renwei,MA Weinan. Study on coupling simulation of gas and coal spontaneous combustion in high gassy and easy spontaneous combustion goaf[J]. Coal Science and Technology,2016,44(4):73-77. doi: 10.13199/j.cnki.cst.2016.04.015
    [12]
    王飞,谷晓玲. 综放工作面采空区抽放注氮与遗煤自燃三耦合关系研究[J]. 煤炭技术,2021,40(2):145-147. doi: 10.13301/j.cnki.ct.2021.02.040

    WANG Fei,GU Xiaoling. Study on coupling relationship between nitrogen injection and coal spontaneous combustion in goaf of fully mechanized top coal caving face[J]. Coal Technology,2021,40(2):145-147. doi: 10.13301/j.cnki.ct.2021.02.040
    [13]
    文虎,王文,程小蛟,等. 不同抽采条件对采空区煤自燃“三带”的影响研究[J]. 矿业安全与环保,2020,47(6):1-7. doi: 10.19835/j.issn.1008-4495.2020.06.001

    WEN Hu,WANG Wen,CHENG Xiaojiao,et al. Study on the effect of different extraction conditions on "three zones" of coal spontaneous combustion in goaf[J]. Mining Safety & Environmental Protection,2020,47(6):1-7. doi: 10.19835/j.issn.1008-4495.2020.06.001
    [14]
    WANG Chaojie,YANG Shengqiang,LI Xiaowei. Simulation of the hazard arising from the coupling of gas explosions and spontaneously combustible coal due to the gas drainage of a gob[J]. Process Safety and Environmental Protection,2018,118:296-306. doi: 10.1016/j.psep.2018.06.028
    [15]
    杜瀚林,于贵生. 高瓦斯易自燃煤层高抽巷瓦斯抽采与浮煤自燃耦合研究[J]. 煤矿安全,2019,50(12):163-169. doi: 10.13347/j.cnki.mkaq.2019.12.037

    DU Hanlin,YU Guisheng. Study on coupling of gas drainage and floating coal spontaneous combustion in high gas drainage roadway of coal seam with high gassy and spontaneous combustion[J]. Safety in Coal Mines,2019,50(12):163-169. doi: 10.13347/j.cnki.mkaq.2019.12.037
    [16]
    XIA Tongqiang,ZHOU Fubao,WANG Xinxin,et al. Controlling factors of symbiotic disaster between coal gas and spontaneous combustion in longwall mining gobs[J]. Fuel,2016,182:886-896. doi: 10.1016/j.fuel.2016.05.090
    [17]
    ZHANG Hemeng,ZHANG Xiaoming,WANG Yongjun,et al. Application of aging effect model in numerical simulation for predicting spontaneous combustion of coal stockpiles[J]. Journal of Thermal Analysis and Calorimetry,2022,147:13847-13860.
    [18]
    ZHANG Hemeng,SASAKI K,ZHANG Xiaoming,et al. Numerical simulations on the self-heating behaviours of coal piles considering aging effect[J]. Combustion Theory and Modelling,2019,23(6):1169-1190.
    [19]
    郝朝瑜,黄戈,王继仁,等. 惰化降温耦合作用下的采空区低温CO2注入流量与温度研究[J]. 火灾科学,2016,25(2):107-113.

    HAO Chaoyu,HUANG Ge,WANG Jiren,et al. Study on CO2 injection effect on flow rate and temperature based on coupling effec of inerting and cooling[J]. Fire Safety Science,2016,25(2):107-113.
    [20]
    ZHUO Hui,QIN Botao,QIN Qinghe,et al. Modeling and simulation of coal spontaneous combustion in a gob of shallow buried coal seams[J]. Process Safety and Environmental Protection,2019,131:246-254.
    [21]
    HUANG Zhi'an,MA Zhenzhen,SONG Shouyi,et al. Study on the influence of periodic weighting on the spontaneous combustion "three-zone" in a gob[J]. Journal of China University of Mining & Technology,2018,55:480-491.
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索

    Figures(10)

    Get Citation
    PDF
    XML

    Article Metrics

    Article views (836) PDF downloads(20) Cited by()
    Proportional views
    Related

    苏ICP备 05016349号-2

    Supported by: Beijing Renhe Information Technology Co. Ltd.  Visits：    

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return