Volume 48 Issue 2
Mar.  2022
Turn off MathJax
Article Contents
Article Navigation >  Journal of Mine Automation  > 2022  >  48(2): 138-146
WEI Xiao, BAO Jiusheng, TAN Fei, et al. Transient condition characteristics and parameter optimization of mine explosion-proof diesel engine[J]. Industry and Mine Automation, 2022, 48(2): 138-146. doi: 10.13272/j.issn.1671-251x.2021080060
Citation: WEI Xiao, BAO Jiusheng, TAN Fei, et al. Transient condition characteristics and parameter optimization of mine explosion-proof diesel engine[J]. Industry and Mine Automation, 2022, 48(2): 138-146. doi: 10.13272/j.issn.1671-251x.2021080060
shu

Transient condition characteristics and parameter optimization of mine explosion-proof diesel engine

doi: 10.13272/j.issn.1671-251x.2021080060
  • 1.

    School of Mechatronic Engineering, China University of Mining and Technology, Xuzhou 221116, China;

  • 2.

    CCTEG Taiyuan Research Institute, Taiyuan 030006, China

  • Received Date: 2021-08-23
  • Rev Recd Date: 2022-02-06
    • Available Online: 2022-03-01
    Abstract
  • The existing explosion-proof diesel engine is transformed by adding explosion-proof flame arrester to the intake system and exhaust system of ground diesel engine. Coal mine underground conditions are complex, explosion-proof diesel engine is often in start-stop, acceleration and deceleration and other transient conditions. And the installation of explosion-proof flame arrester leads to serious obstruction of diesel intake and exhaust, aggravating the hysteresis of intake and exhaust system under transient conditions, and seriously deteriorating the transient conditions characteristics. In order to solve this problem, the steady-state simulation model of explosion-proof diesel engine is established by GT-POWER, and the transient condition control model of explosion-proof diesel engine is established by Simulink, and the transient simulation model of explosion-proof diesel engine is formed by coupling the transient condition control model with the steady-state simulation model. Based on the transient simulation model of explosion-proof diesel engine, the dynamic performance of explosion-proof diesel engine under two typical transient conditions of constant speed and variable torque and constant torque and variable speed is simulated and analyzed. The results show that under the transient condition of constant speed and variable torque, compared with the diesel engine before the explosion-proof transformation, the air-fuel ratio of the explosion-proof diesel engine decreases faster, the maximum burst pressure in the cylinder decreases, and the torque hysteresis is more obvious. Moreover, the faster torque rises, the more serious the hysteresis effect. Under the transient condition of constant torque and variable speed, the air-fuel ratio of explosion-proof diesel engine decreases with the increase of speed, but the process of increasing speed with small load has little effect on the air-fuel ratio. In order to optimize the parameters of explosion-proof diesel engine, the effects of injection advance angle and the number of flame arrester barriers on the power and emission performance of explosion-proof diesel engine are analyzed by simulation. The results show that the maximum burst pressure, maximum combustion temperature, friction torque and power in the cylinder all increase with the increase of the injection advance angle, the volume fraction of CO and HC decreases with the increase of the injection advance angle, and the volume fraction of NOx increases with the increase of the injection advance angle. With the increase in the number of intake and exhaust explosion-proof flame arrester fences, the maximum burst pressure in the cylinder of the explosion-proof diesel engine increases and the maximum combustion temperature decreases. The increase of the number of intake and exhaust explosion-proof flame arrester fences has a negligible effect on the friction torque and power of the explosion-proof diesel engine, but it can inhibit the exhaust emission concentration to a certain extent. Properly increasing the fuel injection advance angle and the number of intake and exhaust explosion-proof flame arrester fences can improve the transient condition characteristics of explosion-proof diesel engines to a certain extent.

     

    • FullText(HTML)
  • loading
    • References(20)
  • [1]
    葛世荣,鲍久圣,曹国华.采矿运输技术与装备[M].北京:煤炭工业出版社,2015.

    GE Shirong,BAO Jiusheng,CAO Guohua.Transportation and hoisting technology and equipments in mining[M].Beijing:China Coal Industry Publishing House,2015.
    [2]
    王烁.煤矿用无轨胶轮车发展现状与展望[J].煤炭与化工,2016,39(5):22-24.

    WANG Shuo.Development and outlook of mine trackless tyred vehicle[J].Coal and Chemical Industry,2016,39(5):22-24.
    [3]
    张良良.小型挖掘机用柴油机瞬态工况模拟及排放性能改进[D].天津:天津大学,2013.

    ZHANG Liangliang.Transient simulation and emission performance improvements of diesel engine using in small excavator[D].Tianjin:Tianjin University,2013.
    [4]
    隋菱歌.增压柴油机瞬态工况性能仿真及优化[D].长春:吉林大学,2012:93-109.

    SUI Lingge.Simulation and optimization of turbo-charged diesel engine performance under transient operations[D].Changchun:Jilin University,2012:93-109.
    [5]
    NILSSON T,FROBERG A,ASLUND J.Optimal operation of a turbocharged diesel engine during transients[J].SAE International Journal of Engines,2012,5(2):571-578.
    [6]
    WILLIAM G,DAVID H,FOSTER D E,et al.Analysis of deviations from steady state performance during transient operation of a light duty diesel engine[J].Cryogenics,2012,5(3):909-922.
    [7]
    王敏,杨蓉,叶洲,等.商用车用电控柴油机增转矩工况的燃烧特性分析[J].内燃机工程,2020,41(5):23-31.

    WANG Min,YANG Rong,YE Zhou,et al.Research on combustion characteristics of electronically controlled diesel engine for commercial vehicles at torque-increasing condition[J].Chinese Internal Combustion Engine Engineering,2020,41(5):23-31.
    [8]
    张龙平,刘忠长,田径,等.车用柴油机瞬态工况试验及性能评价方法[J].哈尔滨工程大学学报,2014,35(4):463-468.

    ZHANG Longping,LIU Zhongchang,TIAN Jing,et al.Experiment and performance evaluation methods for automotive diesel engines under transient operation conditions[J].Journal of Harbin Engineering University,2014,35(4):463-468.
    [9]
    国家安全生产监督管理总局,国家煤矿安全监察局.煤矿安全规程(2016)[M].北京:煤炭工业出版社,2016.

    State Administration of Work Safety,State Administration of Coal Mine Safety.Coal mine safety regulations(2016)[M].Beijing:China Coal Industry Publishing House,2016.
    [10]
    刘海军,侯献军.进/排气边界对高原柴油机缸内制动的数值模拟[J].内燃机学报,2021,39(5):409-416.

    LIU Haijun,HOU Xianjun.Numerical simulation of the effect of intake and exhaust boundary on the in-cylinder braking of a plateau diesel engine[J].Transactions of CSICE,2021,39(5):409-416.
    [11]
    孙丹丹,王铁,张瑞亮,等.加装防爆组件对防爆柴油机性能的影响[J].科学技术与工程,2016,16(20):175-179.

    SUN Dandan,WANG Tie,ZHANG Ruiliang,et al.Effect of the explosion-proof components on flameproof diesel engine performance[J].Science Technology and Engineering,2016,16(20):175-179.
    [12]
    谭飞,鲍久圣,葛世荣,等.矿用防爆柴油机关键技术研究现状与展望[J].煤炭科学技术,2018,46(9):176-182.

    TAN Fei,BAO Jiusheng,GE Shirong,et al.Research status and prospect of key technologies for mine explosion-proof diesel engines[J].Coal Science and Technology,2018,46(9):176-182.
    [13]
    彭振.矿用防爆柴油机尾气后处理技术研究[D].徐州:中国矿业大学,2021.

    PENG Zhen.Study on exhaust aftertreatment technology of mining flameproof diesel engine[D].Xuzhou:China University of Mining and Technology,2021.
    [14]
    雷基林,王东方,邓晰文,等.稳定和过渡工况下柴油机活塞顶面瞬态热负荷变化规律[J].农业工程学报,2018,34(21):65-73.

    LEI Jilin,WANG Dongfang,DENG Xiwen,et al.Transient heat load variation of piston top surface under steady and transition conditions[J].Transactions of the Chinese Society of Agricultural Engineering,2018,34(21):65-73.
    [15]
    宫唤春.插电式混合动力汽车控制策略与建模[J].机械设计与制造,2021(3):106-109.

    GONG Huanchun.Control strategy and modeling of plug-in hybrid electric vehicles[J].Machinery Design & Manufacture,2021(3):106-109.
    [16]
    隋菱歌,刘忠长,韩永强,等.增压柴油机EGR阶跃工况瞬态响应特性仿真分析[J].燃烧科学与技术,2011,17(4):301-307.

    SUI Lingge,LIU Zhongchang,HAN Yongqiang,et al.Simulation analysis of transient response of turbocharged diesel engine under EGR step change operation[J].Journal of Combustion Science and Technology,2011,17(4):301-307.
    [17]
    马朝臣,王恒军.车用涡轮增压器瞬态响应性测试方法[J].哈尔滨工程大学学报,2020,41(9):1255-1260.

    MA Chaochen,WANG Hengjun.A measuring method of transient response ability for turbochargers of internal combustion engine[J].Journal of Harbin Engineering University,2020,41(9):1255-1260.
    [18]
    王俊,申立中,文奕钧,等.大气压力对小型农用柴油机怠速工况燃烧与排放的影响[J].农业工程学报,2020,36(15):73-79.

    WANG Jun,SHEN Lizhong,WEN Yijun,et al.Effects of atmospheric pressure on combustion and emission of a small agricultural diesel engine at idle condition[J].Transactions of the Chinese Society of Agricultural Engineering,2020,36(15):73-79.
    [19]
    杨海涛,续彦芳,畅志明,等.喷油提前角对柴油机燃烧特性的影响分析[J].内燃机,2017(3):50-53.

    YANG Haitao,XU Yanfang,CHANG Zhiming,et al.Influence of diesel fuel injection advance angle on combustion characteristic[J].Internal Combustion Engines,2017(3):50-53.
    [20]
    梁胜龙,马俊.基于CFD柴油机进气系统防爆栅栏结构优化设计[J].机械设计与制造,2020(9):167-171.

    LIANG Shenglong,MA Jun.Structural optimization design of explosion-proof fence in diesel engine intake system based on CFD[J].Machinery Design & Manufacture,2020(9):167-171.
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article views (188) PDF downloads(21) Cited by()
    Proportional views
    Related

    苏ICP备 05016349号-2

    Supported by: Beijing Renhe Information Technology Co. Ltd.  Visits：    

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return